欧美VIBOSS老人

新聞動態
 講解關于電阻爐修爐的相關注意事項

講解關于電阻爐修爐的相關注意事項:
Interpretation of the relevant matters needing attention about resistance furnace repairing the furnace:
1、爐墻擺放要穩固,兩墻之間的間隙要勻稱,如有缺磚或間隙太大時,應補磚堵塞,以防漏料。
1, furnace wall to solid, the gap between the two walls to symmetry, such as lack of brick or when the gap is too big, should fill brick block, in case of leakage of material.
2、清理存放支柱的基坑時,抓斗和操作人員嚴禁同時入坑,以防意外。山東電爐
2, cleaning deposit pillar of foundation pit, grab and operators are strictly prohibited at the same time into the pit, to prevent accidents.
3、清理電極保護圈四周粘附的乏料及硬塊和端墻上粘附的雜物及端墻上面的積料。
Adhesion of spent around 3, clean up the electrode skirts and lumps and side wall to the end product of the wall material and debris.
4、支柱上的絕緣磚脫落1/3和爐墻端頭接連脫落3塊磚時,不應繼續使用,應立即修理。
(4) and pillar of insulating brick fall off a third end off 3 piece and furnace wall brick, should not continue to use, shall be immediately repaired.
5、安裝支柱和爐墻時,必須采用閉鎖式吊鉤。并于吊裝之前在爐底鋪撒1~2厘米厚的木粉,以保護爐底和防止漏電。
5, installing a pillar and furnace wall, locking hook type must be used. And before hoisting in furnace bottom spread of 1 ~ 2 cm thick wood powder, in order to protect the furnace bottom and prevent leakage.
6、爐底乏料用水澆透后,拆除支柱和小墻。拆除小墻時,嚴禁一次吊卸兩塊爐墻,應從中間向兩頭依次吊卸。待爐底和爐頭電極下乏料全部清入水池后,方準吊裝支柱和爐墻。清抓爐底乏料時,防止爐底邊磚掉入水池,邊磚如有缺少,應及時補齊。
After 6, furnace bottom lack water to soak, demolition of pillar and small wall. Dismantle small wall, it is strictly prohibited to a discharge two pieces of furnace wall, should from the middle to the two ends hanging in turn. For furnace bottom and furnace head spent under electrode material after all clear into the pool, the hoisting pillars and furnace wall. Clear grasp furnace bottom waste material, to prevent the furnace bottom brick falling into the pool, if there is a lack of edge brick, should be timely completion.
7、大小爐墻上粘附的乏料清理干凈,透氣孔全部鑿通。吊裝爐墻支柱時,上下操作人員必須配合好,支柱要垂直吊放到底,如有歪斜,需經扎入木楔校正后,方準人工摘鉤。
7, the size of the furnace wall adhesion, the spent material is clean air holes all the chisel. Hoisting furnace wall pillar, the operator must cooperate well, up and down vertical sling the pillar to the end, if you have skewed, subject to Pierce the wedge after correction, the artificial picking hook.
吊裝小墻時,墊好乏料,防止向里傾倒。吊裝大小墻時,須把護鉤掛牢后方準人工摘鉤。未經操作者的同意,吊車工嚴禁下落支柱或爐墻,以免支柱或爐墻歪斜,砸傷操作人員。
When hoisting the little wall, mat well spent, prevent to the dump. When hoisting the size of the wall, of the hook the firm behind the artificial unhooking. Crane operators are strictly prohibited without the permission of the operator's whereabouts pillar or wall, pillar or wall to avoid skew, crushing operations staff.

本文山東電爐生產銷售公司發表提供,詳情請關注公司官方網站:http://www.izmitchip.com/

 
 油罐車海底閥 鋼鋁復合暖氣片 淄博不銹鋼管廠家 燃氣回轉爐 天津紙盒
濟南金岳電爐制造有限公司 版權所有(C)2014   網絡支持   股票代碼: 002095 著作權聲明 網站管理 魯ICP備14033186號-1
欧美VIBOSS老人